optimization-utilization-agrobacterium-mediated-transient-protein

Optimization and Utilization of <em>Agrobacterium</em>-mediated Transient Protein Production in <em>Nicotiana</em>

Agrobacterium-mediated transient protein production in plants is a promising approach to produce vaccine antigens and therapeutic proteins within a short ...

Fraunhofer USA Center for Molecular Biotechnology

The global spread of highly pathogenic avian influenza virus (H5N1 subtype) has promoted efforts to develop human vaccines against potential pandemic outbreaks. However, current platforms for influenza vaccine production are cumbersome, limited in scalability and often require the handling of live infectious virus. We describe the production of hemagglutinin from the A/Indonesia/05/05 strain of H5N1 influenza virus by transient expression in plants, and demonstrate the immunogenicity and protective efficacy of the vaccine candidate in animal models. Immunization of mice and ferrets with plant-derived hemagglutinin elicited serum hemagglutinin-inhibiting antibodies and protected the ferrets against challenge infection with a homologous virus. This demonstrates that plant-derived H5 HA is immunogenic in mice and ferrets, and can induce protective immunity against infection with highly pathogenic avian influenza virus. Plants could therefore be suitable as a platform for the rapid, large-scale production of influenza vaccines in the face of a pandemic.

Plant-derived hemagglutinin protects ferrets against challenge infection with the A/Indonesia/05/05 strain of avian influenza.

The expression of proteins in plants both transiently and via permanently transformed lines has been demonstrated by a number of groups. Transient plant expression systems, due to high expression levels and speed of production, show greater promise for the manufacturing of biopharmaceuticals when compared to permanent transformants. Expression vectors based on a tobacco mosaic virus (TMV) are the most commonly utilized and the primary plant used, Nicotiana benthamiana, has demonstrated the ability to express a wide range of proteins at levels amenable to purification. N. benthamiana has two limitations for its use; one is its relatively slow growth, and the other is its low biomass. To address these limitations we screened a number of legumes for transient protein expression. Using the alfalfa mosaic virus (AMV) and the cucumber mosaic virus (CMV) vectors, delivered via Agrobacterium, we were able to identify three Pisum sativum varieties that demonstrated protein expression transiently. Expression levels of 420 +/- 26.24 mg GFP/kgFW in the green pea variety speckled pea were achieved. We were also able to express three therapeutic proteins indicating promise for this system in the production of biopharmaceuticals.

Transient protein expression in three Pisum sativum (green pea) varieties.

Highly pathogenic avian influenza (HPAI) viruses of the H5N1 subtype have been identified as a potential pandemic threat by the World Health Organization (WHO). Since 1997, these viruses have been spreading from Asia to Europe and Africa with increasing genetic and antigenic diversities. Vaccination is the preferred strategy for the prevention and control of influenza infections and the availability of a system for the rapid engineering and production of vaccines is required in the event of an influenza pandemic. In this study, we engineered and produced recombinant hemagglutinin (HA) from A/Bar-headed Goose/Qinghai/1A/05 (clade 2.2) and A/Anhui/1/2005 (clade 2.3) in Nicotiana benthamiana plants. Immunization of mice with these plant-derived HA antigens elicited serum hemagglutination inhibition (HI) and virus neutralization (VN) antibodies. These results suggest the utility of our plant-expression system for recombinant influenza vaccine production.

Immunogenicity of hemagglutinin from A/Bar-headed Goose/Qinghai/1A/05 and A/Anhui/1/05 strains of H5N1 influenza viruses produced in Nicotiana benthamiana plants.

In 2009, a novel H1N1 swine influenza virus was isolated from infected humans in Mexico and the United States, and rapidly spread around the world. Another virus, a highly pathogenic avian influenza virus of the H5N1 subtype, identified by the World Health Organization as a potential pandemic threat in 1997, continues to be a significant risk. While vaccination is the preferred strategy for the prevention and control of influenza infections, the traditional egg-based approach to producing influenza vaccines does not provide sufficient capacity and adequate speed to satisfy global needs to combat newly emerging strains, seasonal or potentially pandemic. Significant efforts are underway to develop and implement new cell substrates with improved efficiency for influenza vaccine development and manufacturing. In recent years, plants have been used to produce recombinant proteins including subunit vaccines and antibodies. The main advantages of using plant systems for the production of vaccine antigens against influenza are their independence from pathogenic viruses, and cost and time efficiency. Here, we describe the large-scale production of recombinant hemagglutinin proteins from A/California/04/09 (H1N1) and A/Indonesia/05/05 (H5N1) strains of influenza virus in Nicotiana benthamiana plants, and their immunogenicity (serum hemagglutination inhibition and virus neutralizing antibodies), and safety in animal models. These results support the testing of these candidate vaccines in human volunteers and also the utility of our plant expression system for large-scale recombinant influenza vaccine production.

Plant-based rapid production of recombinant subunit hemagglutinin vaccines targeting H1N1 and H5N1 influenza.

Malaria is a serious and sometimes fatal mosquito-borne disease caused by a protozoan parasite. Each year, it is estimated that over one million people are killed by malaria, yet the disease is preventable and treatable. Developing vaccines against the parasite is a critical component in the fight against malaria and these vaccines can target different stages of the pathogen's life cycle. We are targeting sexual stage proteins of P. falciparum which are found on the surface of the parasite reproductive cells present in the mosquito gut. Antibodies against these proteins block the progression of the parasite's life cycle in the mosquito, and thus block transmission to the next human host. Transmission blocking vaccines are essential to the malaria eradication program to ease the disease burden at the population level. We have successfully produced multiple versions of the Pfs25 antigen in a plant virus-based transient expression system and have evaluated these vaccine candidates in an animal model. The targets are expressed in plants at a high level, are soluble and most importantly, generate strong transmission blocking activity as determined by a standard membrane feeding assay. These data demonstrate the feasibility of expressing Plasmodium antigens in a plant-based system for the economic production of a transmission blocking vaccine against malaria.

Antibodies to plant-produced Plasmodium falciparum sexual stage protein Pfs25 exhibit transmission blocking activity.

Plasmodium falciparum is transmitted to a new host after completing its sexual cycle within a mosquito. Developing vaccines against the parasite sexual stages is a critical component in the fight against malaria. We are targeting multiple proteins of P. falciparum which are found only on the surfaces of the sexual forms of the parasite and where antibodies against these proteins have been shown to block the progression of the parasite's life cycle in the mosquito and thus block transmission to the next human host. We have successfully produced a region of the Pfs230 antigen in our plant-based transient-expression system and evaluated this vaccine candidate in an animal model. This plant-produced protein, 230CMB, is expressed at approximately 800 mg/kg in fresh whole leaf tissue and is 100% soluble. Administration of 230CMB with >90% purity induces strong immune responses in rabbits with high titers of transmission-blocking antibodies, resulting in a greater than 99% reduction in oocyst counts in the presence of complement, as determined by a standard membrane feeding assay. Our data provide a clear perspective on the clinical development of a Pfs230-based transmission-blocking malaria vaccine.

A plant-produced Pfs230 vaccine candidate blocks transmission of Plasmodium falciparum.

Influenza virus is a globally important respiratory pathogen that causes a high degree of annual morbidity and mortality. Significant antigenic drift results in emergence of new, potentially pandemic, virus variants. The best prophylactic option for controlling emerging virus strains is to manufacture and administer pandemic vaccines in sufficient quantities and to do so in a timely manner without impacting the regular seasonal influenza vaccine capacity. Current, egg-based, influenza vaccine production is well established and provides an effective product, but has limited capacity and speed.

A plant-based system for rapid production of influenza vaccine antigens.

The increased worldwide awareness of seasonal and pandemic influenza, including pandemic H1N1 virus, has stimulated interest in the development of economic platforms for rapid, large-scale production of safe and effective subunit vaccines. In recent years, plants have demonstrated their utility as such a platform and have been used to produce vaccine antigens against various infectious diseases. Previously, we have produced in our transient plant expression system a recombinant monomeric hemagglutinin (HA) protein (HAC1) derived from A/California/04/09 (H1N1) strain of influenza virus and demonstrated its immunogenicity and safety in animal models and human volunteers. In the current study, to mimic the authentic HA structure presented on the virus surface and to improve stability and immunogenicity of the HA antigen, we generated trimeric HA by introducing a trimerization motif from a heterologous protein into the HA sequence. Here, we describe the engineering, production in Nicotiana benthamiana plants, and characterization of the highly purified recombinant trimeric HA protein (tHA-BC) from A/California/04/09 (H1N1) strain of influenza virus. The results demonstrate the induction of serum hemagglutination inhibition antibodies by tHA-BC and its protective efficacy in mice against a lethal viral challenge. In addition, the immunogenic and protective doses of tHA-BC were much lower compared with monomeric HAC1. Further investigation into the optimum vaccine dose and/or regimen as well as the stability of trimerized HA is necessary to determine whether trimeric HA is a more potent vaccine antigen than monomeric HA.

A plant-produced H1N1 trimeric hemagglutinin protects mice from a lethal influenza virus challenge.

The potential use of Bacillus anthracis as a bioterrorism weapon threatens the security of populations globally, requiring the immediate availability of safe, efficient and easily delivered anthrax vaccine for mass vaccination. Extensive research efforts have been directed toward the development of recombinant subunit vaccines based on protective antigen (PA), the principal virulence factor of B. anthracis. Among the emerging technologies for the production of these vaccine antigens is our launch vector-based plant transient expression system. Using this system, we have successfully engineered, expressed, purified and characterized full-length PA (pp-PA83) in Nicotiana benthamiana plants using agroinfiltration. This plant-produced antigen elicited high toxin neutralizing antibody titers in mice and rabbits after two vaccine administrations with Alhydrogel. In addition, immunization with this vaccine candidate protected 100% of rabbits from a lethal aerosolized B. anthracis challenge. The vaccine effects were dose-dependent and required the presence of Alhydrogel adjuvant. In addition, the vaccine antigen formulated with Alhydrogel was stable and retained immunogenicity after two-week storage at 4°C, the conditions intended for clinical use. These results support the testing of this vaccine candidate in human volunteers and the utility of our plant expression system for the production of a recombinant anthrax vaccine.

A plant-produced protective antigen vaccine confers protection in rabbits against a lethal aerosolized challenge with Bacillus anthracis Ames spores.

Malaria transmission blocking vaccines (TBVs) are considered an effective means to control and eventually eliminate malaria. The Pfs25 protein, expressed predominantly on the surface of the sexual and sporogonic stages of Plasmodium falciparum including gametes, zygotes and ookinetes, is one of the primary targets for TBV. It has been demonstrated that plants are an effective, highly scalable system for the production of recombinant proteins, including virus-like particles (VLPs). We engineered VLPs (Pfs25-CP VLP) comprising Pfs25 fused to the Alfalfa mosaic virus coat protein (CP) and produced these non-enveloped hybrid VLPs in Nicotiana benthamiana plants using a Tobacco mosaic virus-based 'launch' vector. Purified Pfs25-CP VLPs were highly consistent in size (19.3±2.4 nm in diameter) with an estimated 20-30% incorporation of Pfs25 onto the VLP surface. Immunization of mice with one or two doses of Pfs25-CP VLPs plus Alhydrogel® induced serum antibodies with complete transmission blocking activity through the 6 month study period. These results support the evaluation of Pfs25-CP VLP as a potential TBV candidate and the feasibility of the 'launch' vector technology for the production of VLP-based recombinant vaccines against infectious diseases.

A plant-produced Pfs25 VLP malaria vaccine candidate induces persistent transmission blocking antibodies against Plasmodium falciparum in immunized mice.

Moneim Shamloul

Fraunhofer USA Center for Molecular Biotechnology

Optimization and Utilization of Agrobacterium-mediated Transient Protein Production in Nicotiana