Name: fabrication of carbon nanotube high-frequency nanoelectronic biosensor for sensing in high ionic strength solutions
Uploaded: 2013-07-22T12:00:00
Description: Watch this Scientific Journal Video about Fabrication of Carbon Nanotube High-Frequency Nanoelectronic Biosensor for Sensing in High Ionic Strength Solutions at JoVE.com

We thank Prof. Paul McEuen at Cornell University for early discussion. The work is supported by the start-up fund provide by the University of Michigan and the National Science Foundation Scalable Nanomanufacturing Program (DMR-1120187). This work used the Lurie Nanofabrication Facility at University of Michigan, a member of the National Nanotechnology Infrastructure Network funded by the National Science Foundation.

1. Catalyst Patterning for SWNT Growth
<ol>
	<li>Begin with a silicon wafer with a low pressure chemical vapor deposition (CVD) grown 500 nm Si3N4/ 500 nm SiO2 film on top.</li>
	<li>Spin coat a layer of photoresist (PR) at 500 rpm for 5 sec and then 4,000 rpm for 40 sec.</li>
	<li>Bake the wafer at 115 &deg;C for 90 sec.</li>
	<li>Use a photomask with rectangular pits for catalysts (Figure 1) and expose the wafer in UV (365 nm) irradiance of 300 mJ/cm2 for 0...

<ol>
	<li>Dekker, C. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Carbon+nanotubes+as+molecular+quantum+wires.">Carbon nanotubes as molecular quantum wires.</a> Phys. Today. 52, 22-28 (1999).</li><li>McEuen, P. L., Fuhrer, M. S., Park, H. K. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Single-walled+carbon+nanotube+electronics.">Single-walled carbon nanotube electronics.</a> IEEE Transactions on Nanotechnology. 1, 78-85 (2002).</li><li>Duan, X. F., Huang, Y., Cui, Y., Wang, J. F., Lieber, C. M. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Indium+phosphide+nanowires+as+building+blocks+for+nanoscale+electronic+and+optoelectronic+devices.">Indium phosphide nanowires as building blocks for nanoscale electronic and optoelectronic devices.</a> Nature. 409, 66-69 (2001).</li><li>Cui, Y., Zhong, Z. H., Wang, D. L., Wang, W. U., Lieber, C. M. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=High+performance+silicon+nanowire+field+effect+transistors.">High performance silicon nanowire field effect transistors.</a> Nano Letters. 3, 149-152 (2003).</li><li>Heller, I., Janssens, A. M., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Identifying+the+mechanism+of+biosensing+with+carbon+nanotube+transistors.">Identifying the mechanism of biosensing with carbon nanotube transistors.</a> Nano Letters. 8, 591-595 (2008).</li><li>Stern, E., Wagner, R., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Importance+of+the+debye+screening+length+on+nanowire+field+effect+transistor+sensors.">Importance of the debye screening length on nanowire field effect transistor sensors.</a> Nano Letters. 7, 3405-3409 (2007).</li><li>Zhang, G. J., Zhang, G., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=DNA+sensing+by+silicon+nanowire:+Charge+layer+distance+dependence.">DNA sensing by silicon nanowire: Charge layer distance dependence.</a> Nano Letters. 8, 1066-1070 (2008).</li><li>Sorgenfrei, S., Chiu, C. -. y., Johnston, M., Nuckolls, C., Shepard, K. L. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Debye+Screening+in+Single-Molecule+Carbon+Nanotube+Field-Effect+Sensors.">Debye Screening in Single-Molecule Carbon Nanotube Field-Effect Sensors.</a> Nano Letters. 11, 3739-3743 (2011).</li><li>Appenzeller, J., Frank, D. J. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Frequency+dependent+characterization+of+transport+properties+in+carbon+nanotube+transistors.">Frequency dependent characterization of transport properties in carbon nanotube transistors.</a> Applied Physics Letters. 84, 1771-1773 (2004).</li><li>Rosenblatt, S., Lin, H., Sazonova, V., Tiwari, S., McEuen, P. L. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Mixing+at+50+GHz+using+a+single-walled+carbon+nanotube+transistor.">Mixing at 50 GHz using a single-walled carbon nanotube transistor.</a> Applied Physics Letters. 87, (2005).</li><li>Kulkarni, G. S., Zhong, Z. H. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Detection+beyond+the+Debye+Screening+Length+in+a+High-Frequency+Nanoelectronic+Biosensor.">Detection beyond the Debye Screening Length in a High-Frequency Nanoelectronic Biosensor.</a> Nano Letters. 12, 719-723 (2012).</li><li>Sazonova, V. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=.">.</a> A Tunable Carbon Nanotube Resonator. , (2006).</li><li>Chen, R. J., Zhang, Y. G., Wang, D. W., Dai, H. J. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Noncovalent+sidewall+functionalization+of+single-walled+carbon+nanotubes+for+protein+immobilization.">Noncovalent sidewall functionalization of single-walled carbon nanotubes for protein immobilization.</a> Journal of the American Chemical Society. 123, 3838-3839 (2001).</li><li>Duffy, D. C., McDonald, J. C., Schueller, O. J. A., Whitesides, G. M. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Rapid+prototyping+of+microfluidic+systems+in+poly(dimethylsiloxane.">Rapid prototyping of microfluidic systems in poly(dimethylsiloxane.</a> Analytical Chemistry. 70, 4974-4984 (1998).</li><li>Zheng, G. F., Patolsky, F., Cui, Y., Wang, W. U., Lieber, C. M. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Multiplexed+electrical+detection+of+cancer+markers+with+nanowire+sensor+arrays.">Multiplexed electrical detection of cancer markers with nanowire sensor arrays.</a> Nature Biotechnology. 23, 1294-1301 (2005).</li><li>Star, A., Han, T. R., Gabriel, J. C. P., Bradley, K., Gruner, G. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Interaction+of+aromatic+compounds+with+carbon+nanotubes:+Correlation+to+the+Hammett+parameter+of+the+substituent+and+measured+carbon+nanotube+FET+response.">Interaction of aromatic compounds with carbon nanotubes: Correlation to the Hammett parameter of the substituent and measured carbon nanotube FET response.</a> Nano Letters. 3, 1421-1423 (2003).</li><li>Besteman, K., Lee, J. O., Wiertz, F. G. M., Heering, H. A., Dekker, C. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Enzyme-coated+carbon+nanotubes+as+single-molecule+biosensors.">Enzyme-coated carbon nanotubes as single-molecule biosensors.</a> Nano Letters. 3, 727-730 (2003).</li><li>Snow, E. S., Perkins, F. K., Houser, E. J., Badescu, S. C., Reinecke, T. L. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Chemical+detection+with+a+single-walled+carbon+nanotube+capacitor.">Chemical detection with a single-walled carbon nanotube capacitor.</a> Science. 307, 1942-1945 (2005).</li><li>Kong, J., Franklin, N. R., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Nanotube+molecular+wires+as+chemical+sensors.">Nanotube molecular wires as chemical sensors.</a> Science. 287, 622-625 (2000).</li><li>Star, A., Tu, E., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Label-free+detection+of+DNA+hybridization+using+carbon+nanotube+network+field-effect+transistors.">Label-free detection of DNA hybridization using carbon nanotube network field-effect transistors.</a> Proceedings of the National Academy of Sciences of the United States of America. 103, 921-926 (2006).</li><li>Patolsky, F., Zheng, G. F., Lieber, C. M. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Nanowire-based+biosensors.">Nanowire-based biosensors.</a> Analytical Chemistry. 78, 4260-4269 (2006).</li><li>Stern, E., Klemic, J. F., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Label-free+immunodetection+with+CMOS-compatible+semiconducting+nanowires.">Label-free immunodetection with CMOS-compatible semiconducting nanowires.</a> Nature. 445, 519-522 (2007).</li><li>Krivitsky, V., Hsiung, L. -. C., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Nanowires+Forest-Based+On-Chip+Biomolecular+Filtering,+Separation+and+Preconcentration+Devices:+Nanowires+Do+it+All.">Nanowires Forest-Based On-Chip Biomolecular Filtering, Separation and Preconcentration Devices: Nanowires Do it All.</a> Nano Letters. 12, 4748-4756 (2012).</li><li>Kong, J., Soh, H. T., Cassell, A. M., Quate, C. F., Dai, H. J. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Synthesis+of+individual+single-walled+carbon+nanotubes+on+patterned+silicon+wafers.">Synthesis of individual single-walled carbon nanotubes on patterned silicon wafers.</a> Nature. 395, 878-881 (1998).</li><li>Liu, G., Velasco, J., Bao, W. Z., Lau, C. N. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Fabrication+of+graphene+p-n-p+junctions+with+contactless+top+gates.">Fabrication of graphene p-n-p junctions with contactless top gates.</a> Applied Physics Letters. 92, (2008).</li><li>Katz, E., Willner, I. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Probing+biomolecular+interactions+at+conductive+and+semiconductive+surfaces+by+impedance+spectroscopy:+Routes+to+impedimetric+immunosensors,+DNA-Sensors,+and+enzyme+biosensors.">Probing biomolecular interactions at conductive and semiconductive surfaces by impedance spectroscopy: Routes to impedimetric immunosensors, DNA-Sensors, and enzyme biosensors.</a> Electroanalysis. 15, 913-947 (2003).</li><li>K'Owino, I. O., Sadik, O. A. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Impedance+spectroscopy:+A+powerful+tool+for+rapid+biomolecular+screening+and+cell+culture+monitoring.">Impedance spectroscopy: A powerful tool for rapid biomolecular screening and cell culture monitoring.</a> Electroanalysis. 17, 2101-2113 (2005).</li><li>Elnathan, R., Kwiat, M., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Biorecognition+Layer+Engineering:+Overcoming+Screening+Limitations+of+Nanowire-Based+FET+Devices.">Biorecognition Layer Engineering: Overcoming Screening Limitations of Nanowire-Based FET Devices.</a> Nano Letters. 12, 5245-5254 (2012).</li></ol>

The growth of carbon nanotubes depends not only on furnace conditions but also substrate cleanliness. The optimal gas flow rate, temperature and pressure for growth have to carefully calibrated and once fixed they are more or less stable. Even with these conditions being met, we found that growth depends on the patterned catalyst area, amount of catalyst and substrate cleanliness. Hence, we incorporated multiple catalyst pit sizes to account for the variability in growth. A one hour high temperature anneal step helped re...

When a charged molecule binds to a SWNT or NW electronic sensor, it can either donate/accept electrons or act as a local electrostatic gate. In either case, the bound molecule can alter the charge density in the SWNT or NW channel, leading to a change in the measured DC conductance of the sensor. A large variety of molecules15-20 have been successfully detected by studying DC characteristics of the nanosensors during such binding events. Even though charge-detection based sensing mechanism has many advantages including label-free detection21, femto-molar sensitivity22, and electronic read out capability15; it is effective only in low ionic strength solutions. In high ionic strength solutions, DC detection is impeded by ionic screening6-8. A charged surface attracts counter-ions from the solution which forms an electrical double layer (EDL) near the surface. The EDL effectively screens off these charges. As the ionic strength of the solution increases, the EDL becomes narrower and the screening increases. This screening effect is characterized by the Debye screening length &lambda;D,
<img alt="Equation 1" fo:src="/files/ftp_upload/50438/50438eq1highres.jpg" src="/files/ftp_upload/50438/50438eq1.jpg" /> 
, where &epsilon; is the dielectric permittivity of the media, kB is the Boltzmann's constant, T is the temperature, q is the electron charge, and c is the ionic strength of the electrolyte solution. For a typical 100 mM buffer solution, &lambda;D is around 1 nm and the surface potential will be completely screened at a distance of a few nm. As the result, most of nanoelectronic sensors based on SWNTs or NWs operate either in dry state20 or in low ionic strength solutions5,15,17,21-22 (c ~ 1 nM - 10 mM); otherwise the sample needs to undergo desalting steps15,23. Point-of-care diagnostic devices need to operate in physiologically relevant ionic strengths at patient site with limited sample processing capability. Hence, mitigating ionic screening effect is critical for development and implementation of POC nanoelectronic biosensors.
We mitigate the ionic screening effect by operating SWNT based nanoelectronic sensor at megahertz frequency range. The protocol provided here details the fabrication of a SWNT transistor based nanoelectronic sensing platform and high frequency mixing measurement for biomolecular detection. The single-walled carbon nanotubes are grown by chemical vapor deposition on substrates patterned with Fe catalysts24. For our SWNT transistors, we incorporate a suspended top-gate25 placed 500 nm above the nanotube, which helps enhance high frequency sensor response and also allows for a compact micro-fluidic chamber to seal the device. The SWNT transistors are operated as high frequency mixers9-11 in order to overcome the background ionic screening effects. At high frequencies, the mobile ions in solution do not have sufficient time to form the EDL and the fluctuating biomolecular dipoles can still gate the SWNT to generate a mixing current, which is our sensing signal. The frequency mixing arises due to the nonlinear I-V characteristics of a nanotube FET. Our detection technique differs from the conventional techniques of charge based detection and impedance spectroscopy26-27. Firstly, we detect biomolecular dipoles at high frequency rather than the associated charges. Secondly, the high transconductance of SWNT transistor provides an internal gain for the sensing signal. This obviates the need for external amplification as in case of high frequency impedance measurements. Recently, other groups have also addressed biomolecular detection in high background concentrations23,28. However, these methods are more involved, requiring complex fabrication or careful chemical engineering of receptor molecules. Our high frequency SWNT sensor incorporates a simpler design and utilizes the inherent frequency mixing property of a nanotube transistor. We are able to mitigate the ionic screening effects, thus promising a new biosensing platform for real-time point-of-care detection, where biosensors functioning directly in physiologically relevant condition are desired.

<table border="1">
	<tbody>
		<tr>
			<td>&nbsp;</td>
			<td>&nbsp;</td>
			<td>&nbsp;</td>
			<td>REAGENTS</td>
		</tr>
		<tr>
			<td>&nbsp;</td>
			<td>&nbsp;</td>
			<td>&nbsp;</td>
			<td>Reagents which were provided within Lurie Nanofabrication Facility (University of Michigan) are marked as LNF in the catalogue column. Chemicals which require protective equipment (gloves, safety goggles, face mask, apron) and/or fume hood are denoted with PPE in comments section.</td>
		</tr>
		<tr>
			<td>Silicon wafers (P-type, &lt;100&gt;, 500-550 &mu;m thick)</td>
			<td>Silicon Valley Microelectronics</td>
			<td>&nbsp;</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>SPR 220 3.0</td>
			<td>Dow (Rohm and Haas)</td>
			<td>Megaposit SPR</td>
			<td>PPE</td>
		</tr>
		<tr>
			<td>AZ 300MIF</td>
			<td>AZ Electronic Material Corporation</td>
			<td>&nbsp;</td>
			<td>PPE</td>
		</tr>
		<tr>
			<td>Acetone</td>
			<td>J T Baker</td>
			<td>9005-05</td>
			<td>PPE</td>
		</tr>
		<tr>
			<td>Isopropanol (IPA)</td>
			<td>J T Baker</td>
			<td>9079-05</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Buffered Hydrofluoric Acid</td>
			<td>Transene</td>
			<td>&nbsp;</td>
			<td>PPE</td>
		</tr>
		<tr>
			<td>1-Pyrene Butanoic Acid, succinimidyl ester</td>
			<td>Molecular Probes</td>
			<td>P130</td>
			<td>PPE</td>
		</tr>
		<tr>
			<td>Biotin PEO Amine</td>
			<td>Thermo Scientific</td>
			<td>EZ- Link PEG2 Biotin, # 21346</td>
			<td>PPE</td>
		</tr>
		<tr>
			<td>Streptavidin</td>
			<td>Invitrogen</td>
			<td>S 888</td>
			<td>PPE</td>
		</tr>
		<tr>
			<td>Dimethylformamide</td>
			<td>MP Biomedicals</td>
			<td>0219514791</td>
			<td>PPE</td>
		</tr>
		<tr>
			<td>Polydimethylsiloxane Elastomer Base and Curing Agent</td>
			<td>Dow Corning</td>
			<td>Sylgard 184 Elastomer Kit</td>
			<td>PPE</td>
		</tr>
		<tr>
			<td>SU-8 2015</td>
			<td>Microchem</td>
			<td>Y111064</td>
			<td>PPE</td>
		</tr>
		<tr>
			<td>SU-8 Developer</td>
			<td>Microchem</td>
			<td>Y020100</td>
			<td>PPE</td>
		</tr>
		<tr>
			<td>Silanizing agent</td>
			<td>Sigma Aldrich</td>
			<td>452807</td>
			<td>PPE</td>
		</tr>
		<tr>
			<td>Hydrogen</td>
			<td>Purity Plus</td>
			<td>LNF</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Ethylene</td>
			<td>Purity Plus</td>
			<td>LNF</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Argon</td>
			<td>Purity Plus</td>
			<td>LNF</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Phosphate Buffer Saline System</td>
			<td>Sigma Aldrich</td>
			<td>PBS1</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>&nbsp;</td>
			<td>&nbsp;</td>
			<td>&nbsp;</td>
			<td>EQUIPMENT</td>
		</tr>
		<tr>
			<td>&nbsp;</td>
			<td>&nbsp;</td>
			<td>&nbsp;</td>
			<td>Equipment provided by Lurie Nanofabrication Facility (University of Michigan) is denoted as LNF in Catalogue column.</td>
		</tr>
		<tr>
			<td>GCA 200 Autostepper</td>
			<td>GCA</td>
			<td>LNF</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Low Pressure Chemical Vapor Deposition Tool</td>
			<td>Tempress</td>
			<td>LNF</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>e-beam Evaporator</td>
			<td>Enerjet</td>
			<td>LNF</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>CNT growth Furnace</td>
			<td>First Nano</td>
			<td>Easy Tube 3000 (LNF)</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Photomasks</td>
			<td>Nanofilm</td>
			<td>LNF</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Petri dish (150mm)</td>
			<td>&nbsp;</td>
			<td>LNF</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Desiccator</td>
			<td>Bel-Art</td>
			<td>F420100000</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Biopsy Punch</td>
			<td>Ted Pella</td>
			<td>15071/78</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Scalpel</td>
			<td>Ted Pella</td>
			<td>548</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Polyethylene Tubing PE-50</td>
			<td>VWR</td>
			<td>20903-414</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Syringe Pump</td>
			<td>New Era Pump Systems</td>
			<td>NE-1000</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Syringe</td>
			<td>Fisher Scientific</td>
			<td>BD Safety-Lok Syringes</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Syringe Needles</td>
			<td>Fisher Scientific</td>
			<td>14-821-13A</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>DAQ card</td>
			<td>National Instruments</td>
			<td>779111-01</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>GPIB connector</td>
			<td>National Instruments</td>
			<td>778032-51</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Lock-in Amplifier</td>
			<td>Stanford Research Systems</td>
			<td>SR 830</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Frequency Generator</td>
			<td>HP Agilent</td>
			<td>8648B, 9kHz -2GHz</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Bias Tee</td>
			<td>Picosecond</td>
			<td>5575A-104</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>Current Preamplifier</td>
			<td>DL Instruments, LLC</td>
			<td>DL 1211</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>BNC cables</td>
			<td>Allied Electronics</td>
			<td>665-xxxx</td>
			<td>&nbsp;</td>
		</tr>
		<tr>
			<td>SMA cables</td>
			<td>Sentro Tech Corp</td>
			<td>SCF65141</td>
			<td>&nbsp;</td>
		</tr>
	</tbody>
</table>

fabrication of carbon nanotube high-frequency nanoelectronic biosensor for sensing in high ionic strength solutions

The unique electronic properties and high surface-to-volume ratios of single-walled carbon nanotubes (SWNT) and semiconductor nanowires (NW) 1-4 make them good candidates for high sensitivity biosensors. When a charged molecule binds to such a sensor surface, it alters the carrier density5 in the sensor, resulting in changes in its DC conductance. However, in an ionic solution a charged surface also attracts counter-ions from the solution, forming an electrical double layer (EDL). This EDL effectively screens off the charge, and in physiologically relevant conditions ~100 millimolar (mM), the characteristic charge screening length (Debye length) is less than a nanometer (nm). Thus, in high ionic strength solutions, charge based (DC) detection is fundamentally impeded6-8.
We overcome charge screening effects by detecting molecular dipoles rather than charges at high frequency, by operating carbon nanotube field effect transistors as high frequency mixers9-11. At high frequencies, the AC drive force can no longer overcome the solution drag and the ions in solution do not have sufficient time to form the EDL. Further, frequency mixing technique allows us to operate at frequencies high enough to overcome ionic screening, and yet detect the sensing signals at lower frequencies11-12. Also, the high transconductance of SWNT transistors provides an internal gain for the sensing signal, which obviates the need for external signal amplifier.
Here, we describe the protocol to (a) fabricate SWNT transistors, (b) functionalize biomolecules to the nanotube13, (c) design and stamp a poly-dimethylsiloxane (PDMS) micro-fluidic chamber14 onto the device, and (d) carry out high frequency sensing in different ionic strength solutions11.

A scanning electron microscope image of SWNT transistor with a suspended top gate is shown in Figure 7a. The gate dimensions are critical for suspension25. The current design dimensions are (length x width x thickness = 25 &mu;m x 1 &mu;m x 100 nm). The gate electrode consists of 50 nm Cr/50 nm Au; a thick chrome layer adds more strength to suspended structure. The suspended structure is confirmed by absence of leakage current between top gate and drain (Figure 7b).
<p cla...

Watch this Scientific Journal Video about Fabrication of Carbon Nanotube High-Frequency Nanoelectronic Biosensor for Sensing in High Ionic Strength Solutions at JoVE.com

Fabrication of Carbon Nanotube High-Frequency Nanoelectronic Biosensor for Sensing in High Ionic Strength Solutions

We describe the device fabrication and measurement protocol for carbon nanotube based high frequency biosensors. The high frequency sensing technique mitigates the fundamental ionic (Debye) screening effect and allows nanotube biosensor to be operated in high ionic strength solutions where conventional electronic biosensors fail. Our technology provides a unique platform for point-of-care (POC) electronic biosensors operating in physiologically relevant conditions.

The unique electronic properties and high surface-to-volume ratios of single-walled carbon nanotubes (SWNT) and semiconductor nanowires (NW) 1-4 make them ...

Research

JoVE Journal

Bioengineering

Fabrication of Electrochemical-DNA Biosensors for the Reagentless Detection of Nucleic Acids, Proteins and Small Molecules

As medicine is currently practiced, doctors send specimens to a central laboratory for testing and thus must wait hours or days to 
receive the results. ...

Hollow Microneedle-based Sensor for Multiplexed Transdermal Electrochemical Sensing

The development of a minimally invasive multiplexed monitoring system for rapid analysis of biologically-relevant molecules could offer individuals ...

Biosensor for Detection of Antibiotic Resistant Staphylococcus Bacteria

A structurally transformed lytic bacteriophage having a broad host range of Staphylococcus aureus strains and a penicillin-binding protein (PBP 2a) ...

Targeted Plasma Membrane Delivery of a Hydrophobic Cargo Encapsulated in a Liquid Crystal Nanoparticle Carrier

The controlled delivery of drug/imaging agents to cells is critical for the development of therapeutics and for the study of cellular signaling processes. ...

Dry Film Photoresist-based Electrochemical Microfluidic Biosensor Platform: Device Fabrication, On-chip Assay Preparation, and System Operation

In recent years, biomarker diagnostics became an indispensable tool for the diagnosis of human disease, especially for the point-of-care diagnostics. An ...

Improved 3D Hydrogel Cultures of Primary Glial Cells for In Vitro Modelling of Neuroinflammation

Improved 3D Hydrogel Cultures of Primary Glial Cells for In Vitro Modelling of Neuroinflammation

In the central nervous system, numerous acute injuries and neurodegenerative disorders, as well as implanted devices or biomaterials engineered to enhance ...

Spontaneous Formation and Rearrangement of Artificial Lipid Nanotube Networks as a Bottom-Up Model for Endoplasmic Reticulum

We present a convenient method to form a bottom-up structural organelle model for the endoplasmic reticulum (ER). The model consists of highly dense ...

Fabricating Multi-Component Lipid Nanotube Networks Using the Gliding Kinesin Motility Assay

Lipid nanotube (LNT) networks represent an in vitro model system for studying molecular transport and lipid biophysics with relevance to the ubiquitous ...

Fabrication of Zero Mode Waveguides for High Concentration Single Molecule Microscopy

In single molecule fluorescence enzymology, background fluorescence from labeled substrates in solution often limits fluorophore concentration to pico- to ...

Generation of Dynamical Environmental Conditions using a High-Throughput Microfluidic Device

Mimicking in vivo environmental conditions is crucial for in vitro studies on complex life machinery. However, current techniques targeting live cells and ...