Name: failure analysis of batteries using synchrotron-based hard x-ray microtomography
Uploaded: 2015-08-26T16:00:00
Description: Watch this Scientific Journal Video about Failure Analysis of Batteries Using Synchrotron-based Hard X-ray Microtomography at JoVE.com

Primary funding for the work was provided by the Electron Microscopy of Soft Matter Program from the Office of Science, Office of Basic Energy Sciences, Materials Sciences and Engineering Division of the U.S. Department of Energy under Contract No. DE-AC02-05CH11231. The battery assembly portion of the project was supported by the BATT program from the Vehicle Technologies program, through the Office of Energy Efficiency and Renewable Energy under U.S. DOE Contract DE-AC02-05CH11231. Hard X-ray microtomography experiments were performed at the Advanced Light Source which is supported by the Director, Office of Science, Office of Basic Energy Sciences, of the U.S. Department of Energy under Contract No. DE-AC02-05CH11231. Katherine J. Harry was supported by a National Science Foundation Graduate Research Fellowship.

1. Electrolyte Preparation
<ol>
	<li>Synthesize a 240 kg/mol &#8211; 260 kg/mol poly(styrene) - block - poly(ethylene oxide) copolymer (SEO) using anionic polymerization.
	<ol>
		<li>Perform all additional sample preparation in an Argon glovebox where the water and oxygen levels are controlled and remain &#60;5 ppm.</li>
		<li>Dissolve 0.3 g of polymer in anhydrous N-methyl-2-pyrrolidone (NMP) with dry lithium bis(trifluoromethane)sulfonimide (LiTFSI) salt. Use a LiTFSI salt to SEO mass ratio of 0.275 and an N...

<ol>
	<li>Bruce, P. G., Freunberger, S. A., Hardwick, L. J., Tarascon, J. M. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Li-O-2+and+Li-S+batteries+with+high+energy+storage.">Li-O-2 and Li-S batteries with high energy storage.</a> Nat Mater. 11, 19-29 (2012).</li><li>Balsara, N. P., Newman, J. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Comparing+the+Energy+Content+of+Batteries,+Fuels,+and+Materials.">Comparing the Energy Content of Batteries, Fuels, and Materials.</a> J Chem Educ. 90, 446-452 (2013).</li><li>Girishkumar, G., McCloskey, B., Luntz, A. C., Swanson, S., Wilcke, W. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Lithium+-+Air+Battery:+Promise+and+Challenges.">Lithium - Air Battery: Promise and Challenges.</a> J Phys Chem Lett. 1, 2193-2203 (2010).</li><li>Selim, R., Bro, P. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Some+observations+on+rechargeable+lithium+electrodes+in+a+propylene+carbonate+electrolyte.">Some observations on rechargeable lithium electrodes in a propylene carbonate electrolyte.</a> J Electrochem Soc. 121, 1457-1459 (1974).</li><li>Aurbach, D., Zinigrad, E., Cohen, Y., Teller, H. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=A+short+review+of+failure+mechanisms+of+lithium+metal+and+lithiated+graphite+anodes+in+liquid+electrolyte+solutions.">A short review of failure mechanisms of lithium metal and lithiated graphite anodes in liquid electrolyte solutions.</a> Solid State Ionics. 148, 405-416 (2002).</li><li>Monroe, C., Newman, J. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Dendrite+Growth+in+Lithium/Polymer+Systems.">Dendrite Growth in Lithium/Polymer Systems.</a> J Electrochem Soc. 150, A1377 (2003).</li><li>Barton, J. L., Bockris, J. O. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=The+Electrolytic+Growth+of+Dendrites+from+Ionic+Solutions.">The Electrolytic Growth of Dendrites from Ionic Solutions.</a> Proc R Soc Ser A. 268, 485-505 (1962).</li><li>Bhattacharyya, R., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=In+situ+NMR+observation+of+the+formation+of+metallic+lithium+microstructures+in+lithium+batteries.">In situ NMR observation of the formation of metallic lithium microstructures in lithium batteries.</a> Nat Mater. 9, 504-510 (2010).</li><li>Chandrashekar, S., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=7Li+MRI+of+Li+batteries+reveals+location+of+microstructural+lithium.">7Li MRI of Li batteries reveals location of microstructural lithium.</a> Nat Mater. 11, 311-315 (2012).</li><li>Arora, P., White, R. E., Doyle, M. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Capacity+fade+mechanisms+and+side+reactions+in+lithium-ion+batteries.">Capacity fade mechanisms and side reactions in lithium-ion batteries.</a> J Electrochem Soc. 145, 3647-3667 (1998).</li><li>Ebner, M., Marone, F., Stampanoni, M., Wood, V. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Visualization+and+Quantification+of+Electrochemical+and+Mechanical+Degradation+in+Li+Ion+Batteries.">Visualization and Quantification of Electrochemical and Mechanical Degradation in Li Ion Batteries.</a> Science. 342, 716-720 (2013).</li><li>Qi, Y., Harris, S. J. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=In+Situ+Observation+of+Strains+during+Lithiation+of+a+Graphite+Electrode.">In Situ Observation of Strains during Lithiation of a Graphite Electrode.</a> J Electrochem Soc. 157, A741-A747 (2010).</li><li>Eastwood, D. S., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Three-dimensional+characterization+of+electrodeposited+lithium+microstructures+using+synchrotron+X-ray+phase+contrast+imaging.">Three-dimensional characterization of electrodeposited lithium microstructures using synchrotron X-ray phase contrast imaging.</a> Chem Commun. , (2014).</li><li>Shui, J. -. L., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Reversibility+of+anodic+lithium+in+rechargeable+lithium&#8211;oxygen+batteries.">Reversibility of anodic lithium in rechargeable lithium&#8211;oxygen batteries.</a> Nat commun. 4, (2013).</li><li>Harry, K. J., Hallinan, D. T., Parkinson, D. Y., MacDowell, A. A., Balsara, N. P. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Detection+of+subsurface+structures+underneath+dendrites+formed+on+cycled+lithium+metal+electrodes.">Detection of subsurface structures underneath dendrites formed on cycled lithium metal electrodes.</a> Nat Mater. 13, 69-73 (2014).</li><li>Baruchel, J., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Advances+in+synchrotron+hard+X-ray+based+imaging.">Advances in synchrotron hard X-ray based imaging.</a> Cr Phys. 9, 624-641 (2008).</li><li>Flannery, B. P., Deckman, H. W., Roberge, W. G., D'Amico, K. L. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Three-Dimensional+X-ray+Microtomography.">Three-Dimensional X-ray Microtomography.</a> Science. 237, 1439-1444 (1987).</li><li>Singh, M., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Effect+of+molecular+weight+on+the+mechanical+and+electrical+properties+of+block+copolymer+electrolytes.">Effect of molecular weight on the mechanical and electrical properties of block copolymer electrolytes.</a> Macromolecules. 40, 4578-4585 (2007).</li><li>Monroe, C., Newman, J. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=The+Impact+of+Elastic+Deformation+on+Deposition+Kinetics+at+Lithium/Polymer+Interfaces.">The Impact of Elastic Deformation on Deposition Kinetics at Lithium/Polymer Interfaces.</a> J Electrochem Soc. 152, A396-1149 (2005).</li><li>Stone, G. M., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Resolution+of+the+Modulus+versus+Adhesion+Dilemma+in+Solid+Polymer+Electrolytes+for+Rechargeable+Lithium+Metal+Batteries.">Resolution of the Modulus versus Adhesion Dilemma in Solid Polymer Electrolytes for Rechargeable Lithium Metal Batteries.</a> J Electrochem Soc. 159, A222-A227 (2012).</li><li>Panday, A., et al. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=Effect+of+Molecular+Weight+and+Salt+Concentration+on+Conductivity+of+Block+Copolymer+Electrolytes.">Effect of Molecular Weight and Salt Concentration on Conductivity of Block Copolymer Electrolytes.</a> Macromolecules. 42, 4632-4637 (2009).</li><li>Schneider, C. A., Rasband, W. S., Eliceiri, K. W. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=NIH+Image+to+ImageJ:+25+years+of+image+analysis.">NIH Image to ImageJ: 25 years of image analysis.</a> Nat methods. 9, 671-675 (2012).</li><li>Henke, B. L., Gullikson, E. M., Davis, J. C. <a target="_blank" href="http://www.ncbi.nlm.nih.gov/entrez/query.fcgi?db=PubMed&cmd=Search&doptcmdl=Citation&defaultField=Title+Word&term=X-Ray+Interactions+-+Photoabsorption,+Scattering,+Transmission+and+Reflection+at+E=50-30,000+Ev,+Z=1-92+(Vol+54,+Pg+181,+1993).">X-Ray Interactions - Photoabsorption, Scattering, Transmission and Reflection at E=50-30,000 Ev, Z=1-92 (Vol 54, Pg 181, 1993).</a> Atom Data Nucl Data. 55, 349-349 (1993).</li></ol>

Hard X-ray microtomography is especially well-suited for air-sensitive samples, like many electrochemically active materials, since the X-rays can penetrate through protective pouch material, enabling facile imaging of the sample without exposure to air. Perhaps the most valuable characteristic of this imaging technique is that the penetrating X-rays allow the user to see inside of the sample without destroying it. Most common imaging techniques, like scanning electron microscopy and traditional optical microscopy, can o...

Researchers are actively investigating battery chemistries with theoretical energy densities over an order of magnitude larger than traditional lithium-ion batteries.1,2 These high-energy-density batteries will make electric vehicles more competitive with their gasoline-powered counterparts.3 However, these new chemistries have several failure modes that preclude their use in commercial technologies. For example, these battery chemistries require a lithium metal anode to achieve large enhancements in energy density; unfortunately, lithium metal is prone to dendrite growth as lithium ions are reduced at the anode surface during charging.4-9 Additionally, breakage of active particles in the cathode and poor adhesion within the battery can cause cell failure.10
Many modes of battery failure occur on the micrometer scale. However, most battery materials are air sensitive making sample preparation for analysis by electron microscopy and traditional optical microscopy difficult. Synchrotron hard X-ray microtomography allows one to visualize the interior of a battery without disassembly.11-14 Furthermore, the technique produces a three-dimensional (3D) reconstruction of the assembled cell making it easy to find locations of failure.15 Finding robust techniques that enable researchers to develop the scientific understanding required to accurately predict the lifetime of a battery is critical for the design of next generation battery technologies. The procedure discussed herein will specifically demonstrate how one can prepare and image model batteries to study the growth of lithium metal dendrites through solid polymer electrolyte membranes.
Computed tomography (CT) scanning is not a new technique and has been used frequently for failure analysis in industry. Synchrotron-based X-ray microtomography is advantageous because the high brightness and flux of the source allow collection of images with high resolution and good signal to noise in a much shorter amount of time.16 Additionally, one can take advantage of the X-ray energy resolution to image at energies around a chemical species&#8217; absorption edge, causing the components containing that chemical species to be identified.17 It was found that the synchrotron source provides sufficient flux to achieve good contrast between lithium metal and solid polymer electrolyte membranes enabling one to image lithium metal dendrites.15
The study discussed herein uses a high modulus, block copolymer electrolyte membrane.18 These high modulus membranes suppress lithium dendrite growth, lengthening the lifetime of batteries.19,20 However, dendrites still eventually puncture the membrane causing the battery to fail by short-circuit. It is important to understand the nature of dendrite formation and growth in these high modulus electrolyte membranes in order to design strategies to prevent their growth.

<table border="0" cellpadding="0" cellspacing="0">
	<tbody>
		<tr>
			<td>Anhydrous N-methyl-2-pyrrolidone&#160;</td>
			<td>MILLIPORE</td>
			<td>MX1396-7</td>
			<td></td>
		</tr>
		<tr>
			<td>Lithium bis(trifluoromethane)sulfonamide</td>
			<td>MILLIPORE</td>
			<td>8438730010</td>
			<td></td>
		</tr>
		<tr>
			<td>Lithium metal</td>
			<td>FMC Lithium</td>
			<td>None</td>
			<td>Lectro Max 100</td>
		</tr>
		<tr>
			<td>Pouch material</td>
			<td>MTI Corporation</td>
			<td>EQ-alf-400-7.5M</td>
			<td></td>
		</tr>
		<tr>
			<td>Nickel tabs</td>
			<td>MTI Corporation</td>
			<td>EQ-PLiB-NTA3</td>
			<td></td>
		</tr>
	</tbody>
</table>

failure analysis of batteries using synchrotron-based hard x-ray microtomography

Imaging morphological changes that occur during the lifetime of rechargeable batteries is necessary to understand how these devices fail. Since the advent of lithium-ion batteries, researchers have known that the lithium metal anode has the highest theoretical energy density of any anode material. However, rechargeable batteries containing a lithium metal anode are not widely used in consumer products because the growth of lithium dendrites from the anode upon charging of the battery causes premature cell failure by short circuit. Lithium dendrites can also form in commercial lithium-ion batteries with graphite anodes if they are improperly charged. We demonstrate that lithium dendrite growth can be studied using synchrotron-based hard X-ray microtomography. This non-destructive imaging technique allows researchers to study the growth of lithium dendrites, in addition to other morphological changes inside batteries, and subsequently develop methods to extend battery life.

When the symmetric lithium-lithium cells described above are cycled at 90 &#176;C, the voltage response looks like that shown in Figure 1. Eventually, lithium dendrites will grow through the electrolyte and cause the cell to fail by short circuit. When this happens, the voltage response to the applied current will drop down to 0.00 V. Dendrites, like the one shown in Figure 2 appear in samples that have failed by short circuit. Non-electrolyte spanning dendrites are also found in the sam...

Watch this Scientific Journal Video about Failure Analysis of Batteries Using Synchrotron-based Hard X-ray Microtomography at JoVE.com

Failure Analysis of Batteries Using Synchrotron-based Hard X-ray Microtomography

Synchrotron-based hard X-ray microtomography is used to image the electrochemical growth of dendrites from a lithium metal electrode through a solid polymer electrolyte membrane.

Failure Analysis Batterijen met synchrotron gebaseerde Hard X-ray Microtomografie

Imaging morphological changes that occur during the lifetime of rechargeable batteries is necessary to understand how these devices fail. Since the advent ...

Research

JoVE Journal

Engineering

Construction and Testing of Coin Cells of Lithium Ion Batteries

Bouw en testen van Coin Cellen van Lithium Ion batterijen

Rechargeable lithium ion batteries have wide applications in electronics, where customers always demand more capacity and longer lifetime.  Lithium ion ...

In Situ Neutron Powder Diffraction Using Custom-made Lithium-ion Batteries

In Situ Neutron Powder Diffraction Using Custom-made Lithium-ion Batteries

In Situ Neutron poederdiffractie behulp Maatwerk Lithium-ion batterijen

Li-ion batteries are widely used in portable electronic devices and are considered as promising candidates for higher-energy applications such as electric ...

Reservoir Condition Pore-scale Imaging of Multiple Fluid Phases Using X-ray Microtomography

Reservoir Conditie Pore-schaal Beeldvorming van Multiple Fluid fasen met behulp van X-ray Microtomografie

X-ray microtomography was used to image, at a resolution of 6.6 &#181;m, the pore-scale arrangement of residual carbon dioxide ganglia in the pore-space ...

Energy Dispersive X-ray Tomography for 3D Elemental Mapping of Individual Nanoparticles

Energie-dispersieve X-stralen Tomografie voor 3D Elemental kaart brengen van individuele nanodeeltjes

Energy dispersive X-ray spectroscopy within the scanning transmission electron microscope (STEM) provides accurate elemental analysis with high spatial ...

Measurement of X-ray Beam Coherence along Multiple Directions Using 2-D Checkerboard Phase Grating

Meting van röntgenbundel coherentie langs meerdere richtingen gebruiken 2-D schaakbord faseraster

A procedure for a technique to measure the transverse coherence of synchrotron radiation X-ray sources using a single phase grating interferometer is ...

Using Synchrotron Radiation Microtomography to Investigate Multi-scale Three-dimensional Microelectronic Packages

Met behulp van Synchrotron Radiation Microtomografie Multi-scale Driedimensionale Microelectronic pakketten Onderzoek

Synchrotron radiation micro-tomography (SR&#181;T) is a non-destructive three-dimensional (3D) imaging technique that offers high flux for fast data ...

Protocol of Electrochemical Test and Characterization of Aprotic Li-O2 Battery

Protocol of Electrochemical Test and Characterization of Aprotic Li-O2 Battery

Protocol van Elektrochemische Test en karakterisering van Aprotische Li-O<sub&gt; 2</sub&gt; Batterij

We demonstrate a method for electrochemical testing of an aprotic Li-O2 battery. An aprotic Li-O2 battery is made of a Li-metal anode, an aprotic ...

Dynamic Pore-scale Reservoir-condition Imaging of Reaction in Carbonates Using Synchrotron Fast Tomography

Dynamische Pore schaal Reservoir voorwaarde beeldvorming van Reaction in carbonaten met synchrotron Fast Tomography

Underground storage permanence is a major concern for carbon capture and storage. Pumping CO2 into carbonate reservoirs has the potential to dissolve ...